SAFE T Y
Flooding and partial sinking of towing vessel Uncle Blue: Investigation report
The National Transportation Safety Board (NTSB) has published an investigation report on the flooding and partial sinking of towing vessel Uncle Blue that took place on March 26, 2023. The towing vessel Uncle Blue was towing one empty barge on the Lower Mississippi River in Ascension Parish, Louisiana, when the vessel began flooding. The six
crewmembers aboard attempted to pump out the vessel but were unsuccessful, and they evacuated to the barge. Damage to the vessel was estimated at $500,000.
Analysis
While pushing a single barge on the Lower Mississippi River, the Uncle Blue flooded and partially sank near mile 184. During salvage, investigators discovered numerous wastage holes in the hull on the port side of the lazarette. They also discovered doubler plates installed on the hull near the wastage holes. Doubler plating can be used as a temporary repair solution; however, because doubler plate repair can lead to increased stress concentrated in the area of the repair, doubler plates are not suitable as a permanent repair for sections of the hull. Given the vessel’s age, the holes found in the hull, and the presence of the doubler plates, the vessel’s hull had not been adequately maintained. Investigators did not identify other potential sources for the flooding; therefore, the wasted steel hull plating in the lazarette was the initial source of the flooding.
Pipe runs (conduits) inside the hull, which had previously been used to allow rods to run the length of the hull, were either corroded or missing where they passed through the voids. These openings allowed water from the lazarette to flood through two voids and, eventually, into the engine room. Thus, the conduits allowed for progressive flooding, which resulted in the partial sinking. The Uncle Blue had only one bilge high-water level sensor, located at the forward end of the engine room. Because the vessel sank by the stern, the float on the sensor would not have lifted until the lazarette and two voids were filled and the aft end of the engine room was inundated with water. Therefore, as it was configured, the bilge high-water level alarm system was ineffective as a means to alert the crew. Had an additional sensor been installed in the lazarette, the crew would have had an earlier indication of the flooding and may have been able to act to address it.
Lessons Learned Inspecting and Repairing Steel Hulls
Steel hulls are susceptible to corrosion, erosion, and damage over time. To avoid flooding or weakening of the hull, it is good marine practice for owners to conduct regular oversight and maintenance of hulls, including between drydock periods. An effective maintenance and hull inspection program should proactively address potential steel wastage, identify hull and watertight integrity deficiencies, and ensure corrosion issues are repaired in a timely manner by permanent means.
Using Doubler Plates for Hull Repairs
Although doubler plating can be used as a temporary repair solution, it is not generally suitable as a permanent repair for a vessel’s hull. Vessel owners should crop out wasted steel on the hull and replace it by inserting new plating instead of covering it up with doubler plating.
Download the report at
https://bit.ly/4eFpGwd.
Briefings
THE REPORT | DEC 2024 | ISSUE 110 | 29
Page 1 |
Page 2 |
Page 3 |
Page 4 |
Page 5 |
Page 6 |
Page 7 |
Page 8 |
Page 9 |
Page 10 |
Page 11 |
Page 12 |
Page 13 |
Page 14 |
Page 15 |
Page 16 |
Page 17 |
Page 18 |
Page 19 |
Page 20 |
Page 21 |
Page 22 |
Page 23 |
Page 24 |
Page 25 |
Page 26 |
Page 27 |
Page 28 |
Page 29 |
Page 30 |
Page 31 |
Page 32 |
Page 33 |
Page 34 |
Page 35 |
Page 36 |
Page 37 |
Page 38 |
Page 39 |
Page 40 |
Page 41 |
Page 42 |
Page 43 |
Page 44 |
Page 45 |
Page 46 |
Page 47 |
Page 48 |
Page 49 |
Page 50 |
Page 51 |
Page 52 |
Page 53 |
Page 54 |
Page 55 |
Page 56 |
Page 57 |
Page 58 |
Page 59 |
Page 60 |
Page 61 |
Page 62 |
Page 63 |
Page 64 |
Page 65 |
Page 66 |
Page 67 |
Page 68 |
Page 69 |
Page 70 |
Page 71 |
Page 72 |
Page 73 |
Page 74 |
Page 75 |
Page 76 |
Page 77 |
Page 78 |
Page 79 |
Page 80 |
Page 81 |
Page 82 |
Page 83 |
Page 84 |
Page 85 |
Page 86 |
Page 87 |
Page 88 |
Page 89 |
Page 90 |
Page 91 |
Page 92 |
Page 93 |
Page 94 |
Page 95 |
Page 96 |
Page 97 |
Page 98 |
Page 99 |
Page 100 |
Page 101 |
Page 102 |
Page 103 |
Page 104 |
Page 105 |
Page 106 |
Page 107 |
Page 108 |
Page 109 |
Page 110 |
Page 111 |
Page 112 |
Page 113 |
Page 114 |
Page 115 |
Page 116 |
Page 117 |
Page 118 |
Page 119 |
Page 120 |
Page 121 |
Page 122 |
Page 123 |
Page 124 |
Page 125 |
Page 126 |
Page 127 |
Page 128 |
Page 129 |
Page 130 |
Page 131 |
Page 132 |
Page 133 |
Page 134 |
Page 135 |
Page 136 |
Page 137 |
Page 138 |
Page 139 |
Page 140 |
Page 141 |
Page 142 |
Page 143 |
Page 144 |
Page 145 |
Page 146 |
Page 147 |
Page 148
