SAFE T Y
Briefings Grains and soya beans cargo claims review
The Swedish Club has released a detailed analysis of cargo claims in relation to grains and soya beans having reviewed 200 bulk carrier claims. To be included in the statistics the claims had to have generated a cost of at least $5,000 and have been made between 2018 and 2022.
The average frequency for the five-year period is 0.056, which means that 5.6% of all bulk carriers have made a grain claim. Since 2019 the Club has seen a steady increase in the frequency of claims.
Grains
During the five year period of the report the most common claims were for shortage (63%) especially during discharge (68%) and these were seen most commonly in North Africa and China.
About 70% of shortage claims occur due to discrepancies between the vessel’s figures and shore figures. In this five-year period there were few claims in China until 2021, but since then Swedish Club said that it had seen a steady increase in the region. Over the entire five-year period, however, most claims were in North Africa.
The increase of claims in China over the last couple of years could be related to the pandemic, Swedish Club said. The severe lockdowns that were seen in many cases delayed the vessel. They also made it difficult for surveyors to attend the vessel for inspection. Crew and stevedores were also more hesitant to interact with each other because of the risk of becoming infected. This led to the crew not being able to verify the cargo operation and taking draft figures. The Club said that it had seen a similar picture with soya bean claims.
Shortage contributed to 44% of the total claims cost, with an average claim cost of $35,000. Although shortage claims appeared to be of relatively low value, the aggregate cost of these claims was significant.
Non contribution towards General Average (GA) contributions made up 20% of the total cost. The average claim cost was $800,000, but this type of claim was not common.
Wet damage made up 13% of the total cost, with an average claim cost of $37,000.
Most cargo claims occurred at the discharge port. These contributed to 68% of all claims and were mainly driven by shortage. Claims during the voyage accounted for 16%, with only 10% of claims taking place in the loading port.
Any errors in manifests regarding quantity, or description of cargo, are subject to customs fines in Tunisia. If a spillage was experienced, the Club said that the crew should record details of the spillage and check the calibration and accuracy of the shore scale. “Take photographs of the cargo spillage from the grabs, hoppers and trucks”, the Club advised.
Soya beans
The global trade of soya beans has undergone continued expansion in recent times, in part due to the increasing demand in China, the largest soya bean importer, for animal feed. The largest soya bean exporters are Brazil and USA, which account for around 80% of the global export market.
The frequency for the five-year period saw 1.1% of all bulk carriers place a soya bean claim. The average claim cost was $54,000. The pandemic had an impact, with vessels forced to stay at anchor for extensive periods. These delays could lead to heat damage – a significant concern with soya bean cargoes.
The most common claim was for shortage at 29%, followed by spontaneous heating at 19% and contamination at 16%.
When compared with grains, shortage made up a considerably smaller percentage of claims (29% vs 44%). This was partly a trading issue, but in addition the statistics were influenced by Covid-related delays.
Spontaneous heating accounted for 41% of the Club’s total cargo claims cost in this category, with an average claim cost of $115,000. Shortage made up 16% of the total cost, with an average claim cost of $29,000. Physical damage contributed to 13% of the total cost, with an average claim cost of $103,000.
The most common cause of damage claim was damage prior to loading, at 23% of total claims. When considering the damage that leads to these claims, 43% of these claims were observed in the loading port, 29% during the voyage, and 14% at the discharge port.
The second most common cause was inherent vice, at 19%. This manifests at the discharge port 50% of the time and during the voyage at 33%.
The third cause was improper cargo handling ship side, at 16%. This category of claim relates to heating damage and wet damage, often caused by rain during loading and discharge.
THE REPORT | DEC 2023 | ISSUE 106 | 25
Page 1 |
Page 2 |
Page 3 |
Page 4 |
Page 5 |
Page 6 |
Page 7 |
Page 8 |
Page 9 |
Page 10 |
Page 11 |
Page 12 |
Page 13 |
Page 14 |
Page 15 |
Page 16 |
Page 17 |
Page 18 |
Page 19 |
Page 20 |
Page 21 |
Page 22 |
Page 23 |
Page 24 |
Page 25 |
Page 26 |
Page 27 |
Page 28 |
Page 29 |
Page 30 |
Page 31 |
Page 32 |
Page 33 |
Page 34 |
Page 35 |
Page 36 |
Page 37 |
Page 38 |
Page 39 |
Page 40 |
Page 41 |
Page 42 |
Page 43 |
Page 44 |
Page 45 |
Page 46 |
Page 47 |
Page 48 |
Page 49 |
Page 50 |
Page 51 |
Page 52 |
Page 53 |
Page 54 |
Page 55 |
Page 56 |
Page 57 |
Page 58 |
Page 59 |
Page 60 |
Page 61 |
Page 62 |
Page 63 |
Page 64 |
Page 65 |
Page 66 |
Page 67 |
Page 68 |
Page 69 |
Page 70 |
Page 71 |
Page 72 |
Page 73 |
Page 74 |
Page 75 |
Page 76 |
Page 77 |
Page 78 |
Page 79 |
Page 80 |
Page 81 |
Page 82 |
Page 83 |
Page 84 |
Page 85 |
Page 86 |
Page 87 |
Page 88 |
Page 89 |
Page 90 |
Page 91 |
Page 92 |
Page 93 |
Page 94 |
Page 95 |
Page 96 |
Page 97 |
Page 98 |
Page 99 |
Page 100 |
Page 101 |
Page 102 |
Page 103 |
Page 104 |
Page 105 |
Page 106 |
Page 107 |
Page 108 |
Page 109 |
Page 110 |
Page 111 |
Page 112 |
Page 113 |
Page 114 |
Page 115 |
Page 116 |
Page 117 |
Page 118 |
Page 119 |
Page 120 |
Page 121 |
Page 122 |
Page 123 |
Page 124 |
Page 125 |
Page 126 |
Page 127 |
Page 128 |
Page 129 |
Page 130 |
Page 131 |
Page 132 |
Page 133 |
Page 134 |
Page 135 |
Page 136 |
Page 137 |
Page 138 |
Page 139 |
Page 140 |
Page 141 |
Page 142 |
Page 143 |
Page 144
