BOILERS
Gettingitright R
EXTREME WEATHER: Call for action on frozen condensate challenge
epresentatives from across the heating industry met at the Heating and Hotwater Industry Council offices (HHIC) to review and discuss the matter of frozen condensate, which caused a high number of domestic boilers to stop working during the recent extreme weather that caused major disruption across the UK as a whole.
The industry is now calling upon the
government for greater enforcement and strengthening of building regulations. An efficient condensing boiler will generate
around two litres of condensate an hour at a temperature of around 30-40°C; this needs to be piped to the waste water system or to a drain. Industry specification and current British
Standard 6798 states that ‘wherever possible, the condensate drainage pipe shall be terminated at an internal foul water discharge point’. Where there is no other option than to run the pipe externally the pipe needs to be increased to at
least a 30mm inside diameter and insulated to help prevent freezing. Greater awareness and enforcement of this
standard is needed as well as more emphasis on supporting solutions such as internal insulation or trace heating products. Stewart Clements, director, HHIC said: “We
called this ‘summit’ to discuss what needs to be done to prevent a repeat of the problems the industry, and of course consumers experienced earlier in the month. It meant looking at existing regulations around boiler installations; preventative measures to protect external pipework from freezing and what advice and guidance do consumers need. “We had a wealth of experience on the day. HHIC together with the Association of Plumbers and Heating Contractors (APHC), the Chartered Institute of Plumbing and Heating Engineering (CIPHE) met with manufacturers and individual heating engineers, recognising that action must be
taken, which speak volumes for the industry. “From the feedback we have received it has become clear that there was a significant proportion of installations that were not installed to current standards and manufacturers’ instructions. That said, we are acutely aware that in extreme weather conditions external pipework carrying water is at risk of freezing, particularly when there is a high wind chill factor. Obviously, it is difficult to legislate against the most extreme weather conditions. However, we believe it is time for the government to act. “Greater enforcement and strengthening of the building regulations will reduce this risk of boiler condensate pipes freezing. Industry will now work with the government to seek the change required. In the meantime, we will continue to advise the consumer and Gas Safe engineer to assess that the condensate discharge pipe is compliant with the manufacturer’s instructions during their boiler service.”
| | | | | | |
...ALL NOW ERP-COMPLIANT
NEXT
Upgraded. Ever-reliable. Ready for ErP – months early.
GENERATION
0345 070 1058
www.heatingandventilating.netAndrews. Built to perform. 24/7 OUT-OF-HOURS ENGINEER SUPPORT
We’re here to support you through the ErP changes.
andrewswaterheaters.co.uk/nextgeneration
May 2018
39
Page 1 |
Page 2 |
Page 3 |
Page 4 |
Page 5 |
Page 6 |
Page 7 |
Page 8 |
Page 9 |
Page 10 |
Page 11 |
Page 12 |
Page 13 |
Page 14 |
Page 15 |
Page 16 |
Page 17 |
Page 18 |
Page 19 |
Page 20 |
Page 21 |
Page 22 |
Page 23 |
Page 24 |
Page 25 |
Page 26 |
Page 27 |
Page 28 |
Page 29 |
Page 30 |
Page 31 |
Page 32 |
Page 33 |
Page 34 |
Page 35 |
Page 36 |
Page 37 |
Page 38 |
Page 39 |
Page 40 |
Page 41 |
Page 42 |
Page 43 |
Page 44 |
Page 45 |
Page 46 |
Page 47 |
Page 48 |
Page 49 |
Page 50 |
Page 51 |
Page 52 |
Page 53
