Artificial Surfaces
up. By this point, the damage has already been done. Although a surface will never look as good as it does on day one, the aim is to look after it with regular routine maintenance to keep it looking and performing as good as it can. If the preventative maintenance is not
conducted, or conducted frequently enough, you will find that contamination will build up within the surface - all the dust and detritus (leaves/twigs that may drop onto the court) will start to decompose, break down and accumulate in the crevasses of the surface. This applies to both hard courts and artificial grass courts. This contamination will then start to clog up the surface, which means that the courts will not drain as well and a dirty/muddy residue is left on the surface. From this, you ultimately start to get
vegetation growth appearing on the surface - moss and algae are one of the biggest problems found with both hard and carpeted courts - and will grow and spread, in the right weather conditions, very quickly. Once this problem appears, it shows that
the preventative maintenance has not been effective enough and now you must react to it. If you catch it early enough, this could entail conducting some more specialist maintenance, such as an initial chemical treatment to kill off the plant and growth, before utilising a system of rotary brushes or vacuums to try and brush out the moss and the algae. If it has been left to really proliferate and
spread, the only real option to look at on a hard court is to use the Replay AquaCourt process. This process is a type of power washing of the surface to remove the detritus and vegetation, and uses a similar principle to our AquaTrax athletics track cleaning process, but is specifically for hard tennis courts and involves a pedestrian machine that uses water jets. It will take about a day to clean a whole
court using the AquaCourt machine. After cleaning, the surface will be restored to an ‘as new’ condition and the team can then look into putting a preventative maintenance programme in place. As an aside, the paint that is used on a
hard court will contain an agent to give the court slip resistance. This can start to wear off over time through play, maintenance and general weathering, particularly on the service and base lines, where it will receive a lot of agitation by players moving around. Therefore, every four or five years the courts will need to be repainted. On a carpeted court, preventative
maintenance will be very similar to that on the hard courts - all about removing surface debris, regularly brushing the surface and using blowers/vacuums to remove any debris. A common problem with carpeted courts is
that the infill, which is there to protect the carpet, often gets migrated out of the surface, especially in the service line/base line areas. If and when this happens, the carpet will tend to wear more quickly. The same areas that you find wear out on a painted hard court are the same areas on a carpeted court that tend to get worn or damaged - potentially to rip or tear. It is important to keep the sand levels at the right height within the carpet, which is done by regularly brushing to get the sand back into the high-wear areas. As with hard courts, debris that is dropped will sit on top of the sand and start to block
up the drainage of the carpet, resulting in problems such as silt, dirt and flooding. To counteract this, our ‘Rejuvenation’ process uses compressed air to take out the existing sand and all contaminates, and redress the carpet with new sand. For over twenty years, this has widely been
recognised as the class-leading method for restoring tennis courts, with both small and large extraction machines available depending on the access and size of facility. Depending on how good a facility’s preventative maintenance programme has been, this process may only need to be done from year seven onwards. This takes roughly a day per court, but helps to extend the life of the court by a further five years. Part of the preventative maintenance
programme could be our ‘Revive’ procedure that cleans the sand infill regularly. A high demand for this service comes from tennis clubs that generally have multiple courts and are dedicated members clubs. As they don’t always have dedicated groundstaff to look after them, and it often falls to committee members and volunteers to do the work, we will get called in every two or three months. The process is a more intense clean, compared to what they would be able to do themselves, and keeps the infill clean and the surface clear of debris. As a general point, particular attention should be paid to the perimeter area and the net lines, as this is where problems start to take hold - these areas don’t get played on and don’t get worn, so they stagnate, allowing moss and algae to quickly grow and spread.
In the case of Aylesbury Tennis Club, whilst
they don’t have high trees to cause a problem with falling leaves, they do have some bushes surrounding the courts. However, rather than debris, the main problem here was an age thing - they hadn’t done a lot of maintenance themselves, nor called anyone in to do it for them. The surface built up a lot of airborne dust, detritus and debris off players’ footwear that went into the infill and started to seal the carpet.
When the surface becomes non-porous,
the rain can’t drain through and begins to lift out the lighter dust and debris from the infill. This then travels around the court and is deposited in lower areas (called silt puddles) on the court. Aylesbury had a lot of surface silt that had been flushed out of the carpet, moved around to the lower areas and left hazardous, slippery areas. A couple of the courts at the bottom end of the club became unplayable because they were so slippery and dangerous. When we went in, we could see that the carpet itself was in good condition; plenty of pile depth left; good construction and no seam failure, but the contamination in the sand was the issue. The remedial action was to run the Rejuvenation process, using compressed air to extract the sand and redress with clean sand. To prevent this happening in the future, the club was encouraged to ‘up’ their routine maintenance both in-house and external. A tractor and brush were purchased to
ensure weekly maintenance, and Replay were contracted to go in four times a year to carry out their Revive process to keep the existing sand clean and prevent a reoccurrence of the problem. The combination of processes restored their courts to ‘as new’ conditions and added an extra five years to the life of them.
PC AUGUST/SEPTEMBER 2015 I 111
A contaminated court can lead to poor drainage and surface flooding
The combination of processes restored their courts to ‘as new’ conditions and added an extra five years to the life of them
”
A court at Aylesbury Tennis urgently in need of a thorough clean
And the same court after intervention from Replay Maintenance
Page 1 |
Page 2 |
Page 3 |
Page 4 |
Page 5 |
Page 6 |
Page 7 |
Page 8 |
Page 9 |
Page 10 |
Page 11 |
Page 12 |
Page 13 |
Page 14 |
Page 15 |
Page 16 |
Page 17 |
Page 18 |
Page 19 |
Page 20 |
Page 21 |
Page 22 |
Page 23 |
Page 24 |
Page 25 |
Page 26 |
Page 27 |
Page 28 |
Page 29 |
Page 30 |
Page 31 |
Page 32 |
Page 33 |
Page 34 |
Page 35 |
Page 36 |
Page 37 |
Page 38 |
Page 39 |
Page 40 |
Page 41 |
Page 42 |
Page 43 |
Page 44 |
Page 45 |
Page 46 |
Page 47 |
Page 48 |
Page 49 |
Page 50 |
Page 51 |
Page 52 |
Page 53 |
Page 54 |
Page 55 |
Page 56 |
Page 57 |
Page 58 |
Page 59 |
Page 60 |
Page 61 |
Page 62 |
Page 63 |
Page 64 |
Page 65 |
Page 66 |
Page 67 |
Page 68 |
Page 69 |
Page 70 |
Page 71 |
Page 72 |
Page 73 |
Page 74 |
Page 75 |
Page 76 |
Page 77 |
Page 78 |
Page 79 |
Page 80 |
Page 81 |
Page 82 |
Page 83 |
Page 84 |
Page 85 |
Page 86 |
Page 87 |
Page 88 |
Page 89 |
Page 90 |
Page 91 |
Page 92 |
Page 93 |
Page 94 |
Page 95 |
Page 96 |
Page 97 |
Page 98 |
Page 99 |
Page 100 |
Page 101 |
Page 102 |
Page 103 |
Page 104 |
Page 105 |
Page 106 |
Page 107 |
Page 108 |
Page 109 |
Page 110 |
Page 111 |
Page 112 |
Page 113 |
Page 114 |
Page 115 |
Page 116 |
Page 117 |
Page 118 |
Page 119 |
Page 120 |
Page 121 |
Page 122 |
Page 123 |
Page 124 |
Page 125 |
Page 126 |
Page 127 |
Page 128 |
Page 129 |
Page 130 |
Page 131 |
Page 132 |
Page 133 |
Page 134 |
Page 135 |
Page 136 |
Page 137 |
Page 138 |
Page 139 |
Page 140 |
Page 141 |
Page 142 |
Page 143 |
Page 144 |
Page 145 |
Page 146 |
Page 147 |
Page 148 |
Page 149 |
Page 150 |
Page 151 |
Page 152 |
Page 153 |
Page 154 |
Page 155 |
Page 156 |
Page 157 |
Page 158 |
Page 159 |
Page 160 |
Page 161 |
Page 162 |
Page 163 |
Page 164