fDo’s and Don’ts Generator 48
S N O W B I
R D S
&
R V T R A V E L E R S
than the drive engine of their tow vehicle or motor home. Te lack of attention comes from their lack of knowledge of their own generator, when I recently asked RV owners at a seminar I had just given them what they had learned one participant remarked that he was going to have to get more intimate with his generator, the seminar made him realize how little he really knew about this appliance. A Cummins Onan RV generator is an investment
I
that can bring you many years of comfort and enjoyment. However, all generators require proper break in, exercising and periodic maintenance for dependable, ongoing performance. Your Operator’s Manual outlines the specific maintenance procedures and service intervals for your particular model. If you do not have an Operators Manual they can be obtained on line at
CumminsOnan.com or at your local Cummins Onan Distributor or Dealer. Take good care of your generator and it will take good care of you. RV maintenance is performed according to the
number of miles you travel. Similarly, generator maintenance is based on hours of running time. If your generator does not come equipped with an hour meter, install one, and place it in an easy to see location near the RV’s electrical panel so you can keep track of the hours your generator runs.
CARE AND MAINTENANCE
believe most RV owners forget that they have another engine on board that should be treated no differently
Te most ignored appliance on your RV! By John Wendt
or Better Generator Performance
The Do’s DO keep your generator clean by wiping it periodically with a clean cloth.
DO turnoff all appliances in cold weather before starting your generator, for best long-term performance.
DO check the operator’s manual for the periodic maintenance schedule.
DO check the exhaust system regularly for damage or leaks. Make sure the exhaust pipe extends out at least one inch beyond the vehicles perimeter.
DO check the air filter periodically by tapping it on a flat surface. Never wash it in solvents or blow it out with an air hose. DO exercise your generator regularly.
DO change your fuel filter. The fuel filter is an often forgotten part of any engine. Your generator has one too. It removes bits of debris from the fuel to prevent clogging the carburetor jets. Over time the fuel filter collects enough material to become plugged which restricts fuel flow and reduces the generators’ power delivery. Be sure to change the fuel filter on a regular maintenance schedule.
The Don’ts DON’T run the generator for long periods of time without using it to power appliances. It wastes fuel and may cause the engine to misfire.
DON’T attempt to adjust the carburetor, governor, choke, etc. yourself DON’T run your generator with the door panel open.
So take a little time and care of your generator and when you need it most it will always be there for you.
John Wendt is a Certified Red Seal Journeyman RV Technician with 35 years in the RV Industry, was an RV Instructor at Okanagan College for 9 years, and has been with Cummins Western Canada for 5 years as the Consumer Products Representative.
Page 1 |
Page 2 |
Page 3 |
Page 4 |
Page 5 |
Page 6 |
Page 7 |
Page 8 |
Page 9 |
Page 10 |
Page 11 |
Page 12 |
Page 13 |
Page 14 |
Page 15 |
Page 16 |
Page 17 |
Page 18 |
Page 19 |
Page 20 |
Page 21 |
Page 22 |
Page 23 |
Page 24 |
Page 25 |
Page 26 |
Page 27 |
Page 28 |
Page 29 |
Page 30 |
Page 31 |
Page 32 |
Page 33 |
Page 34 |
Page 35 |
Page 36 |
Page 37 |
Page 38 |
Page 39 |
Page 40 |
Page 41 |
Page 42 |
Page 43 |
Page 44 |
Page 45 |
Page 46 |
Page 47 |
Page 48 |
Page 49 |
Page 50 |
Page 51 |
Page 52 |
Page 53 |
Page 54 |
Page 55 |
Page 56 |
Page 57 |
Page 58 |
Page 59 |
Page 60 |
Page 61 |
Page 62 |
Page 63 |
Page 64 |
Page 65 |
Page 66 |
Page 67 |
Page 68 |
Page 69 |
Page 70 |
Page 71 |
Page 72 |
Page 73 |
Page 74 |
Page 75 |
Page 76 |
Page 77 |
Page 78 |
Page 79 |
Page 80