Technology
Getting easier, getting lighter New soft-fibre based standing rigging solutions have many advantages
The use of Armare Ropes’ PBO-Zylon fibres for the standing rigging of high-end raceboats from 25-28ft up to around 70-80ft is well proven and brings advantages equivalent to and in some cases greater than carbon rigging, yet at a fraction of the cost. Armare has been producing
PBO-Zylon for standing rigging for 20 years and has built thousands of individual customcables during that time. The Italian firmis also ropes official supplier to Emirates Team New Zealand andmany Class 40s and Imoca
60s.Most of its PBO- Zylon cables are retrofitted to existing boats. Customsolutions for interface and other potential problems can be created within short lead times. Key criteria for standing rigging
include minimal elongation under load (axial stiffness), weight and finished diameter. Despite its lower cost, PBO-Zylon can outperform carbon micro rod in all these areas. In lab tests against equivalent
29m long carbon micro rods, Armare PBO Zylon showed broadly equal elongation up to a load of 1,500 daN with both materials having around 0.05 per cent elongation. However, the PBO-Zylon was better at higher loads of 3,000 daN (about half the MWL), where elongation averaged 0.1222 per cent, while the figure for carbon micro rod was more than a quarter higher at 0.157 per cent. With a weight of 5.4kg, the PBO
Zylon cable is 10 per cent lighter than the carbon micro rod cable. It’s also narrower, with 13.8mm diameter versus 14.5mm, which helps reduce aero drag. When replacing rod rigging, PBO Zylon costs well under one third as much as a carbon alternative. Compared with rod rigging, the
benefits of Armare’s PBO-Zylon are enormous, including a 5:1 weight advantage over Nitronic 50 rod sized to give the same elongation under
load. In practice it’s possible to reduce both weight and elongation. It’s easy to underestimate the
scale of the benefit this reduction of weight aloft brings. On many yachts 1kg in the rig has an equivalence to 3-4kg in the keel bulb. Saving weight in the rig can therefore significantly increase righting moment, allowing the boat to carry more sail in a given wind speed. Pitching and rolling are also reduced, minimising the loss of speed from these factors and giving a more comfortable motion. The only downside is a greater
requirement for periodic inspections and a shorter overall lifespan. Nevertheless, PBO-Zylon is still seen as a reliable and very cost-effective option for many owners of high- performance craft. Last year, for instance, Armare Ropes signed agreements to supply standing rigging to the Melges 32 class. The higher axial rigidity of its PBO-Zylon improves performance of these boats, especially in gusty conditions, where the vessel’s response and acceleration is faster and more immediate. Armare’s in-house engineers also
developed new rigging terminals and backstays for various one design classes, including the Melges and the Cape 31, which the company says were “immediately welcomed with great enthusiasm for their careful and very refined aesthetics.” These are similarly well finished aesthetically and provide a more immediate response that “translates into greater thrust on the sails and less loss of power.” Further benefits of PBO Zylon is that it’s easy to handle and to roll into coils, which facilitates shipping, installation and maintenance. What about longevity and reliability? To date no cable supplied by Armare has failed within the manufacturer’s stated life limit
Above: PBO- Zylon rigging cables are light and perform very well under high loads even when compared with carbon cables. They are also
comparatively inexpensive
and some owners have continued to use cables well beyond this time. Armare CEO Stefano Finco points
out that, while there’s some debate between manufacturers as to longevity, ‘we all tend to be very conservative, even if the cable is constructed in a good way.’ He adds: ‘lifespan is strictly connected to the type of boat and the application.’ Armare recommends that cables
are returned to the factory every three years, where they can be checked for excess elongation. At the same time Armare’s technicians will also look at wear points in the terminals and check the pins. This process allows for a lifespan of six to eight years, depending on the application on board. The structural fibres are protected
by the Dyneema cover, plus layers of engineering plastic that protect against UV light, humidity, dust, and salt. In the event of mechanical damage covers can be replaced in the factory, creating a cable that Finco says is ‘like new, providing that the structural fibres have not been damaged.’ For the majority of owners, the
most surprising aspect of Amare’s PBO-Zylon standing rigging is the cost. While this varies depending on the boat and application on board, it’s typically only 40 per cent of the cost of carbon standing rigging. That ought to make upgrading to PBO- Zylon a very easy decision.
www.armareropes.com
❑ SEAHORSE 67
N. BROLLO
Page 1 |
Page 2 |
Page 3 |
Page 4 |
Page 5 |
Page 6 |
Page 7 |
Page 8 |
Page 9 |
Page 10 |
Page 11 |
Page 12 |
Page 13 |
Page 14 |
Page 15 |
Page 16 |
Page 17 |
Page 18 |
Page 19 |
Page 20 |
Page 21 |
Page 22 |
Page 23 |
Page 24 |
Page 25 |
Page 26 |
Page 27 |
Page 28 |
Page 29 |
Page 30 |
Page 31 |
Page 32 |
Page 33 |
Page 34 |
Page 35 |
Page 36 |
Page 37 |
Page 38 |
Page 39 |
Page 40 |
Page 41 |
Page 42 |
Page 43 |
Page 44 |
Page 45 |
Page 46 |
Page 47 |
Page 48 |
Page 49 |
Page 50 |
Page 51 |
Page 52 |
Page 53 |
Page 54 |
Page 55 |
Page 56 |
Page 57 |
Page 58 |
Page 59 |
Page 60 |
Page 61 |
Page 62 |
Page 63 |
Page 64 |
Page 65 |
Page 66 |
Page 67 |
Page 68 |
Page 69 |
Page 70 |
Page 71 |
Page 72 |
Page 73 |
Page 74 |
Page 75 |
Page 76 |
Page 77 |
Page 78 |
Page 79 |
Page 80 |
Page 81 |
Page 82 |
Page 83 |
Page 84 |
Page 85 |
Page 86 |
Page 87 |
Page 88 |
Page 89 |
Page 90 |
Page 91 |
Page 92 |
Page 93 |
Page 94 |
Page 95 |
Page 96 |
Page 97 |
Page 98 |
Page 99 |
Page 100 |
Page 101 |
Page 102 |
Page 103 |
Page 104 |
Page 105 |
Page 106 |
Page 107 |
Page 108 |
Page 109 |
Page 110 |
Page 111 |
Page 112
