HEAT RECOVERY
part of your Net Zero strategy
What is heat recovery from
HRFR is the technology that captures the waste heat from a refrigeration or air conditioning system and uses it to heat water. Heat Recovery systems are NOT heat pumps and they do not use any power or to function.
The aim of a fridge system is to move heat from where you don’t want it and expel it outdoors. This expelled heat is a wasted resource that can be used to reduce carbon emissions if collected and used as a heat source. The heat can be transferred to water through high efficiency heat exchangers for use in potable water* heating or space heating.
director of DK Heat Recovery, talks heat recovery from road to Net Zero for the
The heat exchange system is in effect a water-cooled condenser and is deployed in the hot gas line. The heated water can be used for domestic or processing use* or for space heating.
(* must comply with EN 1717 so plate heat exchangers are not acceptable)
By heating water using waste heat there is a consequent reduction in the use of other energy sources that might be used for heating water e.g., gas, electricity, oil and therefore a reduction in carbon emissions. Based on
research commissioned by DEFRA in 2016, if 15% of waste heat from food sector refrigeration were captured in this way, we would not need Sizewell C. In other words, heat recovery from refrigeration not only reduces carbon emissions but also reduces the demand for new infrastructure.
Energy gets used twice, the ultimate in energy efficiency.
The payback on heat recovery from refrigeration can be very rapid often measured in months rather than years, depending on how much hot water/ heat is needed and how much duty the refrigeration / air conditioning delivers. The way in which you finance the technology can help justify it too. Upfront cash is sometimes hard to find in amongst the clamour for this investment or that repair. However, the short paybacks or the ready availability of ‘green finance’ helps. There are companies which have decided to seed their Net Zero campaign with cash for heat recovery and used the savings to finance the rest of their programme. Very forward-thinking.
What are the barriers to
The most common barrier is the refrigeration engineer who doesn’t fully understand the technology and fears that the refrigerant will over condense and cause the system to operate incorrectly. This is not the case with heat recovery from refrigeration as all systems are fitted with pressure controls that protect the system. The refrigeration system is always in charge of how much heat is sent to the heat recovery system.
Building Services Forum qp 3 BSEE
May24.indd 1 10 BUILDING SERVICES & ENVIRONMENTAL ENGINEER MAY 2024 17/4/24 16:44
Second is the ever-increasing rate at which freon gasses are being phased out. With the looming expectation that they will be replacing their fridge plant soon, many organisations put off considering heat recovery. The paybacks can be so short that the system will pay for itself long before the plant gets renewed. If your switch is imminent, consider heat recovery from refrigeration as an integral part of the project as the best and most cost- effective time to add a heat recovery system is when installing new fridge.
The third barrier is government policy. All we hear about is energy generation, not energy reduction. The value of energy consumption reduction has not yet really been taken on board at Westminster. There is plenty of cash for generation and carbon capture, but wouldn’t it be better for the environment to fund not using energy in the first place? Interesting to note that the former Minister of State for Net Zero, Graham Stuart, called heat recovery from refrigeration a ‘no brainer’ when visiting a food manufacturing business in his constituency that had a newly installed unit in 2017.
By viewing heat recovery from refrigeration as a business stream, forward-looking refrigeration contractors will be joining the Net Zero economy with consequent CSR / ESG benefits to their organisation. In addition, and more importantly, they will offer a new service to their existing clients that will save them money and help their Net Zero plans, without adding infrastructure. Moreover, by recognising and marketing heat recovery from refrigeration as a mainstream, all year round offering, new clients will be attracted offering business growth opportunities.
Read the latest at:
www.bsee.co.uk
Page 1 |
Page 2 |
Page 3 |
Page 4 |
Page 5 |
Page 6 |
Page 7 |
Page 8 |
Page 9 |
Page 10 |
Page 11 |
Page 12 |
Page 13 |
Page 14 |
Page 15 |
Page 16 |
Page 17 |
Page 18 |
Page 19 |
Page 20 |
Page 21 |
Page 22 |
Page 23 |
Page 24 |
Page 25 |
Page 26 |
Page 27 |
Page 28 |
Page 29 |
Page 30 |
Page 31 |
Page 32 |
Page 33 |
Page 34 |
Page 35 |
Page 36 |
Page 37 |
Page 38 |
Page 39 |
Page 40 |
Page 41 |
Page 42 |
Page 43 |
Page 44 |
Page 45 |
Page 46
