GROUNDWORKS
49
Smart greywater recycling helps to deliver exclusive Kensington homes
Park development by CPC Group, located in one of London’s most exclusive residential neighbourhoods. To meet planning and building control regulations, mains water demand was required to stay below a strict 110 litres daily allocation for each resident of 25 individually-designed homes in the Holland Park Estate in Kensington.
A
On-Demand Water Reuse London-based consulting engineers chapmanbdsp specified a pioneering new on-demand greywater recycling technology from water management systems specialist SDS, in one of the first installations of the technology in the UK. The bespoke system enabled the waste water from baths and showers to be collected, treated in the digitally-controlled greywater system, then reused for toilet flushing throughout the building. By reusing water, the overall mains demand
was calculated to reduce by at least 15% to an average of 90 litres per person per day, a very low level and significantly below the current national average of 140 litres.
Reduced Mains Water Demand “In keeping with 80 Holland Park’s carefully-considered and individually- designed apartments, the bathroom fittings
SDS's greywater system uses the latest filtration technologies.
n innovative, smart water-recycling technology has been installed as part of the prestigious 80 Holland
are of a very high specification,” explains Dave Honey, principle public health engineer with chapmanbdsp. “Greywater recycling is an efficient and sustainable technology that has enabled water that would otherwise have gone to waste to be reused, thereby offsetting the increased flow rates from the high-end sanitaryware.” “Planning conditions required the development to comply with Building Regulations Part G and the water efficiency criteria for new dwellings, normally 125 litres per person per day, but reduced further to 110 litres per person by a planning condition,” he added. Collaboration between the chapmanbdsp engineers, SDS and the development’s environmental engineers was essential right from the design stage to exceed the required water efficiency performance and overcome the site constraints.
Accurate Usage Calculations Honey explains: “The SDS team provided excellent expert support and produced clear calculations to show precisely how much water their system would process and subsequently provide. This information was also invaluable to our client’s environmental engineers to demonstrate the sustainable benefits of the development.” The groundbreaking SDS on-demand greywater recycling system could fit in the building’s plant room much more easily than conventional membrane bioreactor (MBR) treatment, which would have been difficult to design around the constraints of the building, said Honey. “By specifying the SDS on-demand
greywater recycling system, the collection and storage tanks, which would be separate in an MBR system, could be combined to create a relatively small footprint. This meant the plant room could be located as centrally as possible and the pipework could also be routed without encroaching on the headroom requirements in the basement car park. “The topography of the site meant it
was difficult to collect waste water from all of the dwellings, unless we buried the system below the basement slab, which wasn’t feasible. We therefore had to ensure that the amount of water collected could yield sufficient to provide flushing for all WCs,” he added.
The 80 Holland Park development
Ultrafiltration Greywater Technology Waste water is collected from 27 outlets around the building via a dedicated network of pipes that are routed to a holding tank in the GWR basement plant room. The collected greywater is pumped through a disk pre-filter system and dosed with a small amount of chlorine before entering the ultrafilters. The ultrafiltration system is a highly-efficient hollow-fibre membrane with automated integral backwash that yields water to near drinking-water standards. The treated water is then stored, ready for
use, in a separate tank and pumped, as needed, to provide flushing of 88 WCs throughout the development. The estimated greywater yield per day is just over 3,000 litres when the development is fully occupied. Offering high-performance efficiency in a
smaller space, the SDS system reuses just enough water to be delivered efficiently throughout the building as it is needed. The scalability of the system means that recycled water can be provided from when the first residents move into the building, then adapt to increasing demand as more people move in. By contrast, an MBR system would require a minimum usage rate to be reached before it could be set in operation.
www.sdslimited.com
ADF NOVEMBER 2021
WWW.ARCHITECTSDATAFILE.CO.UK
Page 1 |
Page 2 |
Page 3 |
Page 4 |
Page 5 |
Page 6 |
Page 7 |
Page 8 |
Page 9 |
Page 10 |
Page 11 |
Page 12 |
Page 13 |
Page 14 |
Page 15 |
Page 16 |
Page 17 |
Page 18 |
Page 19 |
Page 20 |
Page 21 |
Page 22 |
Page 23 |
Page 24 |
Page 25 |
Page 26 |
Page 27 |
Page 28 |
Page 29 |
Page 30 |
Page 31 |
Page 32 |
Page 33 |
Page 34 |
Page 35 |
Page 36 |
Page 37 |
Page 38 |
Page 39 |
Page 40 |
Page 41 |
Page 42 |
Page 43 |
Page 44 |
Page 45 |
Page 46 |
Page 47 |
Page 48 |
Page 49 |
Page 50 |
Page 51 |
Page 52 |
Page 53 |
Page 54 |
Page 55 |
Page 56 |
Page 57 |
Page 58 |
Page 59 |
Page 60 |
Page 61 |
Page 62 |
Page 63 |
Page 64 |
Page 65 |
Page 66 |
Page 67 |
Page 68 |
Page 69 |
Page 70 |
Page 71 |
Page 72 |
Page 73 |
Page 74 |
Page 75 |
Page 76 |
Page 77 |
Page 78 |
Page 79 |
Page 80 |
Page 81 |
Page 82 |
Page 83 |
Page 84
